Pannelli di controllo per pompe antincendio diesel secondo normativa EN 12845
Gli SCF840-D-U sono progettati per soddisfare e superare i requisiti della norma EN 12845 e sono certificati da CEPREVEN; sono strumenti ad alte specifiche che applicano la tecnologia più avanzata. Offrono caratteristiche impareggiabili come comunicazione, web integrato, configurazioni, versatilità e robustezza.
I pannelli di controlloSCF840-D-U regolano il processo di avviamento e di arresto delle Pompe Antincendio Diesel e le proteggono attraverso l’azione degli allarmi collegati e generati dal controllore stesso; visualizzano i valori e le informazioni più rilevanti, gestire anche la comunicazione con l’operatore e con entrambi gli elementi di contorno e il centro remoto presidiato.
| Nº | STANDARDS & TECHNICAL RULES |
|---|---|
| 1 | Standard EN 12845 Ed.2015 |
| 2 | Standard UNE 23500 Ed.2021 & Ed. 2012 |
| 3 | Standard UNI 10779 Ed. 2014 |
| 4 | Standard IEC 61439-1 Ed. 2011 Low-voltage switchgear and controlgear assemblies |
| 5 | EMC: EN50130-4:2011 / IEC 62599-2:2010 / EN61000-6-3:2007 |
| 6 | Electrical safety:EN61010-1:2011 |
| Nº | RANGE OF PRODUCTS (according to the type plate) | ||
|---|---|---|---|
| 1 | Nominal supply voltage | 110Vac – 230 Vac (Consult other voltages) | |
| 2 | Nominal frecuency | 50Hz / 60Hz. | |
| PANEL MODELS ACCORDING TO BATTERY CHARGERS |
SCF840-D-N 12070 | SCF840-D-N 12100 | SCF840-D-N 24050 | SCF840-D-N 24100 |
| Nominal Voltage | 12 Vdc | 12Vdc | 24 Vdc | 24 Vdc |
| Nominal Amps | 7 A | 100 A | 5 A | 10 A |
| DIN Power | 96,6 W | 138,0 W | 138,0 W | 276,0 W |
| Batteries capacity (C10) | 200 Ah | 285 Ah | 142,5 Ah | 285 Ah |
| Nº | CONSTRUCTIVE FEATURES | ||
|---|---|---|---|
| 1 | CE marking: EMC | EN50130-4:2011 / IEC 62599-2:2010 / EN61000-6-3:2007 | |
| 2 | CE marking; Electrical safety | EN61010-1:2011 | |
| 3 | Enclosure | Ingress protection rating according to EN 60529:2018: IP65 | |
| 4 | Protection against impacts degree according to EN60068-2-75:2014: IK10 | ||
| 5 | Fireproof degree: The fire is extinguished in <30s with dripping | ||
| 6 | Display | TFT full colour 3,5″ 480×272 px | |
| 7 | Cabling | Free of halogens | |
| 8 | Fire resistance: RZ1 according to EN50200 (Max: 830º / 90min) | ||
| 9 | Working temperatures | From -5ºC to 40ºC | |
| 10 | Relative humidity (without condensation) | Functional from 20 to 95%. | |
| 11 | Cooling | Natural convection | |
| 12 | Maximum altitude | 2000m | |
| 13 | Degree of contamination | 2 | |
| 14 | Overvoltage category | II | |
| 15 | Environment | CEM-I | |
| 16 | Anti-vibration protection | EN60068-2-6:2008 | |
| Nº | MEASURING INSTRUMENTS IN THE DISPLAY | |
|---|---|---|
| 1 | Batteries | 2 Voltmeter: Battery voltage |
| 2 | 2 Ammeter: Battery charging Amp | |
| 4 | 1 Battery equalization timer | |
| 5 | Engine | 1 Fuel tank level meter |
| 6 | 1 Oil pressure gauge (transducer not included) | |
| 7 | 1 Engine wáter thermometer (transducer not included) | |
| 8 | 1 Engine oil thermometer (transducer not included) | |
| 9 | 1 Engine speed meter (sensor not included) | |
| 10 | Pump | 1 Pump demand pressure meter (transducer not included) |
| 4 | 1 Pump suction pressure meter (transducer not included) | |
| 12 | 1 Flow meter ( manual introduction / 4⁄20mA sender not included) | |
| 13 | System | 1 Voltmenter Vac supply voltaje |
| 14 | 1 Room temperature thermometer | |
| Nº | PUMP & SYSTEM PROTECTION |
|---|---|
| 1 | MAINS FAILURE |
| 2 | OVER SPEED |
| 3 | LOW OIL PRESSURE |
| 4 | HIGH TEMPERATURE ENGINE |
| 5 | LOW TEMPERATURE ENGINE |
| 6 | LOW FUEL LEVEL |
| 7 | LOW BATTERY A VOLTAGE |
| 8 | LOW BATTERY B VOLTAGE |
| 9 | CHARGER A FAULT |
| 10 | CHARGER B FAULT |
| 11 | HEATER PROTECTION TRIPPED |
| 12 | CRANK ENGINE VOLTAGE FAIL |
| 13 | FAILED TO START |
| 14 | LOW DISCHARGE PRESSURE |
| 15 | LOW RESERVOIR TANK |
| 16 | LOW PRIMING TANK |
| 17 | SPEED SIGNAL FAULT |
| 18 | PRESSURE SWITCH SHORT-CIRCUIT |
| 19 | PRESSURE SWITCH OPEN-CIRCUIT |
| 20 | ELECTRIC MAINS FREQUENCY FAIL |
| 21 | FAULT COMMUNICATIONS I/O |
| 22 | FAULT COMMUNICATIONS WIFI |
| 23 | CRANKING LEVERS FAULT |
| 24 | LOW COOLANT TEMPERATURE |
| 25 | DC VOLTAGE FAIL |
| 26 | HIGH BATTERY A VOLTAGE |
| 27 | HIGH BATTERY B VOLTAGE |
| 28 | BATTERY A DEFECTIVE |
| 29 | BATTERY B DEFECTIVE |
| 30 | WATER PRESSURE SENSOR FAULT |
| 31 | SURGE ARRESTER FAULT |
| 32 | LOW FLOW COOLANT WATER |
| 33 | LOW AMBIENT TEMPERATURE |
| 34 | HIGH AMBIENT TEMPERATURE |
| 35 | ROOM TEMPERATURE TRANSDUCER FAILURE |
| 36 | TRIPPED HEATER PROTECTION |
| 37 | FAULT CRANKING MOTOR VOLTAGE |
| 38 | FAULT AUXILIARY ALTERNATOR |
| 1 | USB connector type AB | Firmware updatin |
| 2 | Wifi | Access to embedded website |
| 3 | Ethernet: Modbus / TCP-IP | PC monitoring: General status of the system and pumps |
| 4 | RS485 Modbus / RTU | PC monitoring: General status of the system and pumps |
| 4 | Voltage free relays | 6 double relays 30 Vdc / 0,3 A |
| 6 | 1 double relay 250 Vac / 10 A |
| Nº | LANGUAGES / OTHER FEATURES |
|---|---|
| 1 | ENGLISH/ ESPAÑOL / ITALIANO / FRANÇAIS / PORTUGUES |
| 2 | Monitored pressure switch lines: Short circuit / open circuit alarm |
| 3 | Monitored connection solenoid box. Cranking levers fault alarm |
| 4 | Pump demand by pressure transducer analog reading of system pressure |
| 5 | Current date and time (RTC with independent battery) |
| 6 | 1200 last events log (starts, alarms, …) |
| 7 | 12,000 latest records of system pressure variation |
| 8 | 50 pressure / Flow pump test récords |
| 9 | Calibration of analog measurements: Pressure / Voltage / Temperature … |
| 10 | Digital and analog inputs and outputs checking of on the display |
| 11 | Accumulate engine operations hours and minutes |
| 12 | Engine cooling circuit management |
| 13 | Engine heating resistence management |
Quadri Antincendio
Quadri Antincendio
SCF8M-E-U Quadro motori elettrici (<200Kw) + jockey (<5,5Kw)
Quadri Antincendio
Quadri Antincendio
Quadri Antincendio
Quadri Antincendio
Quadri Antincendio
Quadri Antincendio
Motori Diesel Antincendio
Quadri Antincendio
Generatori Diesel